JKOwners Forum banner

1 - 10 of 10 Posts

·
Registered
Joined
·
62 Posts
Discussion Starter #1
Tell me about your install experience with the Rubicon Express 3.5" Superflex kit.

I've finally made up my mind to order it along with a pair of Tom Woods shafts for my JK Unlimited.

Were there any suprises/gliches with the install?
 

·
Vendor
Joined
·
2,531 Posts
I just installed it this week with a couple of buddies, we had an entire garage with a lift and every tool you could imagine and it went very smooth. Without the lift in the garage and everything else i could see it being kind of a pain in the a$$, trying to get your control arms and everything to the correct length and hooked up. The front swaybar might be a little tricky also if you laying under it. All and all though it went pretty smooth.
 

·
Registered
Joined
·
119 Posts
1) GET AN ADJ. REAR TRACK BAR(FULL TRACKTION) AND FREQUENTLY CHECK IT. AS SPRINGS SETTLE THE UPPER CONTROL ARMS MAY RUB FRAME.
2) i SEE YOU ARE GETTING DRIVE SHAFTS, I HAVE 3500mi AND THEY NEED REPLACING.
3) i HAVE TOYO 315/75R16...35x12.5 AND RUN 28-30psi WAS RUNNING 32psi DRASTIC IMPRVEMENT.
4)STEERING IS HORRIBLE, ITS LIGHT AND WANDERS. BAD CASE OF BUMP STEER. I AM GETTING DRIVE SHAFTS AND NEED THE CAMBER ADJ. BUT SONDS LIKE I MAY NEED ADJ LOWER CONTROL ARMS. I BOUGHT THIS KIT FOR EASE OF INSTAL.
 

·
Registered
Joined
·
119 Posts
REMEMBER ITS NOT A CORVETTE, A LOT! OF BODY ROLL. nOT BASHING IT AT ALL, JUST LETTING YOU KNOW MY ISSUES SO YOU DONT HAVE THEM. IT KICKS ASS IT THE ROCKS!! VERY SMOOTH ON ROAD, I WENT WITH THE BILSTEIN MONOTUBES. CHECK OUT THE RAUSCH CREEK 1/5 VIDEO AT JKFORUM. MINE IS THE ONE WITH SHARK TEETH! GOOD LUCK
 

·
Registered
Joined
·
111 Posts

·
Registered
Joined
·
62 Posts
Discussion Starter #8
I bet you will! :laughing:

So feeling like a kid the night before a trip to Disneyland? I am!

Looking forward to helping you on the isntall, almost as much as I'm looking forward to my order coming in!
 

·
Registered
Joined
·
111 Posts
I'm not getting any sleep tonight. It feels like I’m 12 and its Christmas Eve.

I'm ready are you?
 
1 - 10 of 10 Posts
Top